Our 2012 FD SLX wagon is on its last legs. It's not really worth spending money on any more, but I couldn't sell it with a clear conscience in its current condition.
It's done ~245,000kms.
It's on its second turbo already, the turbo was replaced with a new genuine Garrett 65,000kms ago, and now the turbo has shaft play and sounds like a siren.
I'm thinking that for the cost of a turbo (~$1300 new), I could probably buy an engine?
Anyone tried just replacing the CHRA? Not sure if this is viable for a VVT turbo, due to the calibration required.
Hyundai Kia U2 D4FB 28201-2A710 CHRA Turbo Core – Turbo BitsOr a cheap Chinese turbo?
http://www.aliexpress.com/i/1622705402.htmlIt's hard to find an FD D4FB with lower kms, are there any other engine swaps that are viable? i.e. will a GD D4FB swap in to an FD? Diesels other than the D4FB (upgrade)?
I've read a few posts on engine swaps, but not seen any successful outcomes.
There are numerous other issues with the car now.
Odd vehicle shake a 60-80km/h under acceleration. Changing engine mounts helped a little. Could be a driveshaft issue? It's not balance/alignment.
Bad injector or pilot injection, injector calibration. Bad diesel engine knock 2500-3000rpm.
Trans has already been repaired once due to flare in 3rd. Replacement drum and clutch pack.
Its just old and tired
